• Ford TIS (Technical Information System) 1990-2004 (DVD)
• Full CD Ford Fiesta 2001 Service Manual
• Using Ford Wiring Diagrams
• Ford Focus Wiring Diagrams
• Ford Ranger 3.0 engine wiring diagram
• Ford Focus 2004 Wiring Diagrams

Contains:

Routine maintenance and servicing

Air cleaner filter element renewal

Air conditioner condenser check

Air conditioner refrigerant charge check

Automatic choke check

Automatic transmission brake band adjustment

Automatic transmission fluid level check

Automatic transmission selector lubrication

Auxiliary drivebelt check

Battery electrolyte level check

Battery terminal check

Brake fluid renewal

Brake pipe and hose check

Brake system seal and hose renewal

Camshaft drivebelt renewal

Crankcase ventilation vent valve renewal

Driveshaft check

Electrical system check

Engine coolant renewal

Engine inlet manifold security check

Engine oil and filter renewal

Engine valve clearance check

Exhaust system check

Final drive oil level check

Fluid leak check

Fluid level checks

Front and rear brake pad check

Fuel filter renewal

Hinge and lock check and lubrication

Hot starting check

Idle mixture check

Idle speed check

Idle speed linkage clean

Ignition system component check

Intensive maintenance

Introduction

Manual gearbox oil level check

Oil filler cap check

Power steering fluid level check

Road test

Roadwheel security check

Seat belt check

Spark plug renewal

Specifications

Steering and suspension security check

Tyre checks

Underbody inspection

Wiper blade check

Air charge temperature sensor - removal and refitting

Alternator - brush renewal

Alternator - removal and refitting

Alternator - testing on the vehicle

Battery - charging

Battery - removal and refitting

Carburettor stepper motor (2.0 litre models) - removal, refitting and

adjustment

Coolant temperature sensor - removal and refitting

Crankshaft speed/position sensor - removal and refitting

Distributor - removal and refitting

Electrical fault-finding - general information

Engine management control module - removal and refitting

Engine management system relays - testing

Fuel temperature sensor - removal and refitting

Fuel trap (carburettor models) - removal and refitting

General information and precautions

HT leads, distributor cap and rotor arm - removal, inspection and

refitting

Ignition coil - testing, removal and refitting

Ignition module (fuel-injection models) - removal and refitting

Ignition timing - checking

Ignition timing and idle speed adjustments

Manifold absolute pressure (MAP) sensor - removal and refitting

Manifold heater (carburettor models) - removal and refitting

Spark plugs - removal, inspection and refitting

Starter motor - brush renewal

Starter motor - removal and refitting

Starter motor - testing on the vehicle

Vehicle speed sensor - removal and refitting

ABS module - removal and refitting

Brake discs - inspection

Brake hydraulic system - bleeding

Brake hydraulic system - fluid renewal

Brake pedal - removal and refitting

Brake pipes and hoses - inspection, removal and refitting

Control module (April 1992 on) - removal and refitting

Front brake disc - removal and refitting

Front brake pads - inspection and renewal

Front caliper - overhaul

Front caliper - removal and refitting

G (gravity) switch (April 1992 on) - removal and refitting

General information

Handbrake cable - adjustment

Handbrake cable - removal and refitting

Handbrake control lever - removal and refitting

Hydraulic unit - removal and refitting

Hydraulic unit accumulator - removal and refitting

Hydraulic unit fluid reservoir - removal and refitting

Hydraulic unit hoses - removal and refitting

Hydraulic unit pressure switch - removal and refitting

Hydraulic unit pump and motor - removal and refitting

Master cylinder (April 1992 on) - removal and refitting

Pedal Travel Sensor (PTS) (April 1992 on) - removal and refitting

Rear brake disc - removal and refitting

Rear brake pads - inspection and renewal

Rear caliper - overhaul

Rear caliper - removal and refitting

Rear disc splash shield - removal and refitting

Vacuum servo unit (April 1992 on) - testing, removal and refitting

Vacuum servo unit check valve (April 1992 on) - removal, testing and refitting

Valve block and pump assembly (April 1992 on) - removal and refitting

Wheel sensors - removal and refitting

Engine oil

SOHC with filter

DOHC with filter

DOHC without filter

V6 with filter